广东工业大学学报 ›› 2020, Vol. 37 ›› Issue (01): 48-52.doi: 10.12052/gdutxb.190078

• 综合研究 • 上一篇    下一篇

生蚝壳作为微生物固化砂土钙源的试验研究

梁仕华1, 林坚鹏1,2, 牛九格1, 冯德銮1, 龚星1, 罗庆姿1   

  1. 1. 广东工业大学 土木与交通工程学院, 广东 广州 510006;
    2. 桂林联勤保障中心 76174部队, 广西 桂林 512200
  • 收稿日期:2019-06-10 出版日期:2020-01-25 发布日期:2019-12-10
  • 通信作者: 林坚鹏(1992-),男,硕士研究生,主要研究方向为微生物岩土,E-mail:837089849@qq.com E-mail:837089849@qq.com
  • 作者简介:梁仕华(1977-),男,副教授,主要研究方向为环境岩土和微生物岩土,E-mail:shihua_l@126.com
  • 基金资助:
    国家自然科学基金资助项目（51508109）；广东省自然科学基金资助项目（2017A030310244）

An Experimental Study of Oyster Shell as Calcium Source for Microbial Solidification

Liang Shi-hua1, Lin Jian-peng1,2, Niu Jiu-ge1, Feng De-luan1, Gong Xing1, Luo Qing-zi1   

  1. 1. School of Civil and Transportation Engineering, Guangdong University of Technology, Guangzhou 510006, China;
    2. Guilin Joint Logistics Support Center of PLA Unit 76174, Guilin 512200, China
  • Received:2019-06-10 Online:2020-01-25 Published:2019-12-10

HTML

PDF (PC)

2753

摘要： 微生物诱导碳酸钙沉淀（microbial induced calcium carbonate precipitation，MICP）是一种新兴的环保地基加固技术，使用该技术需消耗大量化学分析级试剂，如尿素、钙盐等，对环境等造成一定的不良影响。基于利用废弃资源的理念，选取厨余垃圾生蚝壳作为MICP固化砂土钙源，并与用硝酸钙、氯化钙作为钙源进行对比。通过无侧限抗压强度试验、渗透试验、碳酸钙质量分数测试、干密度试验和扫描电镜试验（SEM）等探讨该方法的可行性。试验结果表明，以生蚝壳为钙源的MICP固化砂柱的平均孔径最大，但其表观孔隙率最低，无侧限抗压强度、渗透系数、碳酸钙质量分数、干密度等物理力学指标均优于化学钙。SEM试验结果显示，不同钙源固化砂柱砂颗粒表面均有碳酸钙沉淀生成，生蚝壳钙源获得的碳酸钙沉淀晶体形态是表面比较粗糙，伴有微小孔隙的球体形态；硝酸钙获得的碳酸钙沉淀是介于球状和棱柱体之间的多棱角的簇状；氯化钙获得的碳酸钙沉淀呈现颗粒相互交错堆积的簇状。

关键词: 微生物诱导碳酸钙沉淀, 生蚝壳, 钙源, 表观孔隙率

Abstract: Microbial-induced calcium carbonate precipitation (MICP) is an emerging environmentally friendly foundation reinforcement technology that requires the consumption of a large number of chemical analysis-grade reagents, such as urea, calcium salts, etc., which have certain adverse effects on the environment. Based on the idea of utilizing waste resources, oyster shells from kitchen waste were selected as calcium sources of MICP solidified sandy soil and compared with chemical calcium sources such as calcium nitrate and calcium chloride. Through unconfined compressive strength test, permeability test, calcium carbonate content test, dry density test and scanning electron microscopy (SEM), the feasibility of oyster shells as calcium source of MICP solidified sand was discussed. The experimental results show that the MICP solidified sand column with raw clam shells as the calcium source has the largest average pore size, but the lowest apparent porosity, and the physical strength indexes such as unconfined compressive strength, permeability coefficient, calcium carbonate content and dry density are all higher than chemical calcium. SEM test results show that different calcium source solidified sand column sand particles have calcium carbonate precipitation on the surface, and the calcium carbonate precipitated crystal obtained from the raw clam shell calcium source has a relatively fine surface with a small pore shape; and nitric acid obtained from calcium carbonate precipitate is in a cluster of polygonal angles between the spherical and prismatic bodies; and calcium chloride obtained from calcium carbonate precipitate exhibits clusters in which the particles are interlaced with each other.

Key words: microbial induced calcium carbonate precipitation (MICP), oyster shell, calcium source, apparent porosity

中图分类号: 

  • TU441
[1] MONTOYA B M, DEJONG J T, BOULANGER R W. Dynamic response of liquefiable sand improved by microbial-induced calcite precipitation[J]. Géotechnique, 2013, 63(4):302-312
[2] CHU J, IVANOV V, NAEIMI M, et al. Optimization of calcium-based bioclogging and biocementation of sand[J]. Acta Geotechnica, 2014, 9(2):277-285
[3] WILEN B M, JIN B, LANT P. The influence of key chemical constituents in activated sludge on surface and flocculating properties[J]. Water Research, 2003, 37(9):2127
[4] CHENG L, SHAHIN M A, CORD-RUWISCH R. Bio-cementation of sandy soil using microbially induced carbonate precipitation for marine environments[J]. Géotechnique, 2014, 64(12):1010
[5] CHOI S G, WU S, CHU J. Biocementation for sand using an eggsheel as calcium source[J]. Journal of Geotechnical & Geoenvironmental Engineering, 2016, 142(10):6016010
[6] LIU L, LIU H, XIAO Y, et al. Biocementation of calcareous sand using soluble calcium derived from calcareous sand[J]. Bulletin of Engineering Geology & the Environment, 2018, 77(4):1781-1791
[7] CHOI S G, JIAN C, BROWN R C, et al. Sustainable biocement production via microbially-induced calcium carbonate precipitation:use of limestone and acetic acid derived from pyrolysis of lignocellulosic biomass[J]. Acs Sustainable Chemistry & Engineering, 2017, 5(6):5183-5190
[8] 李峰. 以牡蛎壳为原料制备食品级添加剂丙酸钙的工艺研究[D]. 西安:西北大学, 2008.
[9] 张海鹏. 用蚝壳制备丙酸钙的研究[J]. 山东化工, 2018, 47(12):31-32
ZHANG H P. Research in calcium propionate preparation with oyster shell[J]. Shandong Chemical Industry, 2018, 47(12):31-32
[10] 梁仕华, 牛九格, 戴君. 循环灌浆次数对微生物固化砂土效果的影响[J]. 工业建筑, 2018, 48(7):22-26
LIANG S H, NIU J G, DAI J. Effect of the number of grouting cycles on bio-cemented sand[J]. Industrial Construction, 2018, 48(7):22-26
[11] 梁仕华, 戴君, 李翔, 等. 不同固化方式对微生物固化砂土强度影响的研究[J]. 工业建筑, 2017, 47(2):82-86
LIANG S H, DAI J, LI X, et al. Study of effects of different curing methods on the strength of bio-cemented sand soil[J]. Industrial Construction, 2017, 47(2):82-86
[12] NIU J G, LIANG S H, GONG X, et al. Experimental study on the effect of grouting interval on microbial induced calcium carbonate precipitation[J]. IOP Conference Series:Earth and Environmental Science, 2018, 186:012071. DOI:10.1088/1755-1315/186/3/012071.
[13] GONG X, NIU J G, LIANG S H, et al. Environmental effect of grouting batches on microbial-induced calcite precipitation[J]. Ekoloji, 2019, 28(107):929-936
[14] 梁仕华, 牛九格, 房采杏, 等. 营养液钙源对微生物固化砂土效果影响的试验研究[J]. 防灾减灾工程学报, 2018, 38(5):781-786
LIANG S H, NIU J G, FANG C X, et al. Experimental study on the effect of nutrient solution calcium sources on bio-cemented sand[J]. Journal of Disaster Prevention and Mitigation Engineering, 2018, 38(5):781-786
[15] 徐日庆, 邓祎文, 徐波, 等. 基于SEM图像的软土接触面积定量研究[J]. 应用基础与工程科学学报, 2016, 24(2):295-303
XU R Q, DENG Y W, XU B, et al. Soft clay contact area quantitative research based on SEM images[J]. Journal of Basic Science and Engineering, 2016, 24(2):295-303
[16] 徐日庆, 邓祎文, 徐波, 等. 基于SEM图像信息的软土三维孔隙率定量分析[J]. 地球科学与环境报, 2015, 37(3):104-110
XU R Q, DENG Y W, XU B, et al. Quantitative analysis of soft clay three-dimensional porosity based on SEM image information[J]. Journal of Earth Sciences and Environment, 2015, 37(3):104-110
No related articles found!
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
版权所有 © 2017 《广东工业大学学报》编辑部
地址：广州市东风东路729号广东工业大学 邮编：510090
电话：020-37626653,020-37626139,020-37626396
邮箱：xbzrb@gdut.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发