低压EGR系统对缸内直喷发动机性能影响的研究

doi:10.12052/gdutxb.200013

广东工业大学学报 ›› 2020, Vol. 37 ›› Issue (05): 82-86.doi: 10.12052/gdutxb.200013

低压EGR系统对缸内直喷发动机性能影响的研究

张盼望¹, 熊锐¹, 吴坚^1,2, 张中威¹, 纪佳圳¹, 李沛焕¹

1. 广东工业大学机电工程学院，广东广州 510006;
2. 广汽集团汽车工程研究院，广东广州 510640

收稿日期:2020-01-13 出版日期:2020-09-17 发布日期:2020-09-17
作者简介:张盼望(1990-)，男，硕士研究生，主要研究方向为汽车节能与排放控制
基金资助:
国家重点研发计划项目(2017YFB0103300)

A Study of the Effect of Low Pressure EGR System on Gasoline Direct Injection Engine Performance

Zhang Pan-wang¹, Xiong Rui¹, Wu Jian^1,2, Zhang Zhong-wei¹, Ji Jia-zhen¹, Li Pei-huan¹

1. School of Electromechanical Engineering, Guangdong University of Technology, Guangzhou 510006, China;
2. Automobile Engineering Research Institute, Guangzhou Automobile Group, Guangzhou 510640, China

Received:2020-01-13 Online:2020-09-17 Published:2020-09-17

摘要/Abstract

摘要： 为研究低压废气再循环系统（Exhaust Gas Recirculation，EGR）对缸内直喷发动机油耗、排放和泵气损失的影响，基于某2.0T缸内直喷发动机，提出了一套低压EGR系统控制策略。试验结果表明，在各个工况下，随着EGR率的升高，比油耗出现降低的情况，泵气损失得到良好改善，排气端的一氧化碳（CO）和氮氧化物（NO_x）含量降低，总碳氢化合物（Total Hydrocarbons，THC）含量略有升高。

关键词: 低压废气再循环, 控制策略, 比油耗, EGR率, 排放的气体

Abstract: In order to study the effect of low-pressure exhaust gas recirculation system (Exhaust Gas Recirculation, EGR) on the fuel consumption, emissions and pumping loss of a direct-injection engine in a cylinder, a set of low-pressure EGR system control strategies is proposed based on a 2.0T direct-injection engine. The test results show that under various operating conditions, as the EGR rate increases, the specific fuel consumption decreases, the pumping loss is improved, and the carbon monoxide (CO) and nitrogen oxide (NO_x) content at the exhaust end decreases. Total Hydrocarbon (THC) content increases slightly.

Key words: exhaust gas recirculation, control strategy, specific fuel consumption, EGR rate, exhaust gas

中图分类号:

TK411+.5

张盼望, 熊锐, 吴坚, 张中威, 纪佳圳, 李沛焕. 低压EGR系统对缸内直喷发动机性能影响的研究[J]. 广东工业大学学报, 2020, 37(05): 82-86.

Zhang Pan-wang, Xiong Rui, Wu Jian, Zhang Zhong-wei, Ji Jia-zhen, Li Pei-huan. A Study of the Effect of Low Pressure EGR System on Gasoline Direct Injection Engine Performance[J]. Journal of Guangdong University of Technology, 2020, 37(05): 82-86.

参考文献

[1] 杨世春, 李君, 李德刚. 缸内直喷汽油机技术发展趋势分析[J]. 车用发动机, 2007(5): 8-13
YANG S C, LI J, LI D G. Direct injection gasoline technology development trend analysis [J]. Vehicle Engine, 2007(5): 8-13
[2] DINGELSTADTR, EWERT S, WERZ M, 等. 废气再循环在汽油机上的潜力[J]. 国外内燃机, 2015, 47(3): 53-56
DINGELSTADTR, EWERT S, WERZM, et al. The potential of exhaust gas recirculation on gasoline engine [J]. Foreign Internal Combustion Engine, 2015, 47(3): 53-56
[3] 翟兆亮, 熊锐, 李广耀. 内外部EGR对柴油HCCI燃烧控制的仿真研究[J]. 广东工业大学学报, 2011, 28(2): 51-55
ZHAI Z L, XIONG R, LI G Y, et al. Simulation of EGR effects on diesel HCCI combustion control [J]. Journal of Guangdong University of Technology, 2011, 28(2): 51-55
[4] 曹爽. 满足国六排放的柴油机性能研究[D]. 大连: 大连理工大学, 2017.
[5] 贾宁, 高定伟, 郭向阳, 等. EGR对增压进气道喷射汽油机的影响研究[J]. 内燃机工程, 2016, 37(2): 43-47
JIA N, GAO D W, GUO X Y, et al. Study on the influence of EGR on turbocharged injector gasoline engine [J]. Chinese Internal Combustion Engine Engineering, 2016, 37(2): 43-47
[6] 高尚志, 潘建考, 杨陈, 等. 低压EGR对GDI发动机燃烧和燃油经济性的影响[J]. 小型内燃机与车辆技术, 2018, 47(6): 7-9
GAO S Z, PAN J K, YANG C, et al. Effect of low pressure EGR on combustion and fuel economy of GDI engine [J]. Small Internal Combustion Engine and Vehicle Technology, 2018, 47(6): 7-9
[7] 秦博, 张宗澜, 林思聪. 低压冷EGR对小型汽油机的节油贡献[J]. 小型内燃机与车辆技术, 2017, 46(4): 19-25
QIN B, ZHANG Z L, LIN S C, et al. Contribution of low-pressure cold EGR to the fuel saving of small gasoline engines [J]. Small Internal Combustion Engine and Vehicle Technology, 2017, 46(4): 19-25
[8] LIU F, PFEIFFERJ. Estimation algorithms for low pressure cooled EGR in spark-ignition engines [J]. SAE International Journal of Engines, 2015, 8(4): 1652-1659
[9] KIWANR, STEFANOPOULOU A, MARTZ J, et al. Effects of differential pressure sensor gauge-lines and measurement accuracy on low pressure EGR estimation error in SI engines[R]. SAE Technical Paper, 2017-01-0531.
[10] OLIN P, MALONEY P. Barometric pressure estimator for production engine control and diagnostics[R]. SAE Technical Paper, 1999-01-0206.
[11] 吉田慎一郎, 伊藤行伸, 平井直树, 等. 低压冷却EGR系统在小型增压式汽油机上的应用[J]. 国外内燃机, 2017, 49(2): 49-53
YOSHIDA S, ITO S, HIRAI N, et al. Application of low pressure cooling EGR system in small supercharged gasoline engine [J]. Foreign Internal Combustion Engine, 2017, 49(2): 49-53
[12] 石垒, 李连豹, 陈钰婷, 等. 缸内直喷增压发动机EGR影响的试验研究[J]. 内燃机, 2017(2): 35-38
SHI L, LI L B, CHEN Y T, et al. Experimental study on EGR influence of direct injection supercharged engine [J]. Internal Combustion Engine, 2017(2): 35-38
[13] 王都, 王俊席, 任鹏飞, 等. 节气门流量模型对天然气发动机控制精度的影响[J]. 内燃机与动力装置, 2013, 30(4): 1-3
WANG D, WANG J X, REN P F, et al. Effects of throttle flow model on control accuracy of natural gas engine [J]. Internal Combustion Engine and Power Plant, 2013, 30(4): 1-3
[14] 聂广论. 汽油机控制单元硬件在环测试系统仿真研究[D]. 长春: 吉林大学, 2018.
[15] 熊家秦, 熊锐, 吴坚, 等. 增量式PID怠速控制策略在发动机上的应用[J]. 广东工业大学学报, 2013, 30(3): 109-111
XIONG J Q, XIONG R, WU J, et al. Application of incremental PID idling control strategy to engines [J]. Journal of Guangdong University of Technology, 2013, 30(3): 109-111

Metrics

Viewed

Full text

Abstract

Cited

Shared

Discussed

低压EGR系统对缸内直喷发动机性能影响的研究

A Study of the Effect of Low Pressure EGR System on Gasoline Direct Injection Engine Performance

HTML

PDF (PC)

摘要/Abstract

引用本文

使用本文

参考文献

相关文章 3

Metrics

本文评价

推荐阅读 0

[1]	吴金成, 谢振东, 伍冠桦, 方秋水, 余红玲. 基于交通一卡通数据的交通状态分析及动态控制研究[J]. 广东工业大学学报, 2017, 34(03): 77-82.
[2]	李学文, 曹平, 刘俊, 孙可平. 基于改进的STATCOM控制策略的研究[J]. 广东工业大学学报, 2010, 27(4): 92-95.
[3]	许立梓；何小敏；李传芳；许首峰； . GENIE30组态软件在涂布生产线上的应用[J]. 广东工业大学学报, 2000, 17(1): 5-9.