广东工业大学学报 ›› 2017, Vol. 34 ›› Issue (05): 80-85.doi: 10.12052/gdutxb.160107

• 综合研究 • 上一篇    下一篇

石灰与水泥固化南沙锌污染软土试验研究

梁仕华1, 罗祺1, 王蒙2, 刘勇健1, 尹应梅1, 江志源1   

  1. 1. 广东工业大学 土木与交通工程学院, 广东 广州 510006;
    2. 交通运输部 南海第一救助飞行队, 广东 珠海 519000
  • 收稿日期:2016-08-20 出版日期:2017-09-09 发布日期:2017-07-10
  • 作者简介:梁仕华(1976-),男,副教授,博士,主要研究方向为环境岩土工程及地下空间工程.
  • 基金资助:
    国家自然科学基金资助项目（51508109）；广东省自然科学基金资助项目（2016A030313692）

An Experimental Study of Nansha Zinc Contaminated Sludge Solidification with Cement and Lime

Liang Shi-hua1, Luo Qi1, Wang Meng2, Liu Yong-jian1, Yin Ying-mei1, Jiang Zhi-yuan1   

  1. 1. School of Civil and Transportation Engineering, Guangdong University of Technology, Guangzhou 510006, China;
    2. The South China Sea No.1 Flying Rescue Team, The Ministry of Transport, Zhuhai 519000, China
  • Received:2016-08-20 Online:2017-09-09 Published:2017-07-10

HTML

PDF (PC)

2966

摘要： 利用石灰与水泥混合固化剂对广州南沙锌污染淤泥进行固化/稳定处理.通过无侧限抗压强度试验和淋滤试验分别对固化土体的力学性能和锌离子浸出率进行研究，得出无侧限抗压强度随固化剂中石灰掺量和龄期的变化关系及石灰掺量与锌离子浸出量之间的变化关系；通过扫描电镜研究了不同配比下固化土样微观结构特征.研究表明：随着石灰掺量的增加，固化土体强度随龄期和石灰掺量均有较大提高，同时锌离子浸出质量浓度有大幅度降低；其中15%水泥+10%石灰修复3 000 mg/kg以下锌污染土锌离子浸出率为零.综合来说，H2（15%水泥+10%石灰）固化修复效果较好，这与固化土体的微观结构中的水化产物有关.

关键词: 南沙软土, 锌离子, 无侧限抗压强度, 淋滤试验, 扫描电镜

Abstract: Zinc pollution sludge in Nansha (Guangzhou) was solidified and stabilized by the lime and cement. The mechanical property of solidified soil and zinc ions leaching rate were studied respectively through the unconfined compressive strength test and leaching test. The relationship of the unconfined compressive strength with the changes of lime dosage and the age has been obtained, meanwhile the relationship of the lime dosage and zinc ions leaching quantity also derived. The solidified soil samples with different ratio of composition are observed that they have different microstructure characteristics by the electronic microscope. Research shows that the strength of solidified soil has significant increase with the increasing of age and the amount of lime, and the zinc ions leaching concentration has greatly reduced. What's more, zinc ions leaching rate in the zinc pollution soil was to zero with the 15% cement+10% lime repair below 3 000 mg/kg. In conclusion, H2 (15% cement+10% lime) has better effect in curing and repairing, which is associated with the microstructure of hydration products of solidified soil.

Key words: Nansha soft soil, zinc ions, the unconfined compressive strength (UCS), leaching test, scanning electronic microscope (SEM)

中图分类号: 

  • X53
[1] 储诚富, 查甫生, 夏磊, 等. 锌污染黏土工程性质的试验研究[J]. 工业建筑, 2015, 45(1):118-121.CHU S F, ZHA F S, XIA L et al. Experiment study of engineering properties of zinc contaminated clay[J]. Industrial Construction, 2015, 45(1):118-121. [2] LASAT M M. Phytoextraction of toxic metals:a review of biological mechanisms[J]. Journal of Environmental Quality, 2001, 31(1):109-120. [3] 王秀丽, 徐建民, 谢正苗, 等. 重金属铜和锌污染对土壤环境质量生物学指标的影响[J]. 浙江大学学报(农业与生命科学版), 2002, 28(2):190-194.WANG X L, XU J M, XIE Z M, et al. Effects of Cu and Zn Contamination on Soil Biological of Environmental Quality[J]. Journal of Zhejiang University (Agric & Life Sci), 2002, 28(2):190-194. [4] 陈同斌, 黄启飞, 高定, 等. 中国城市污泥的重金属含量及其变化趋势[J]. 环境科学学报, 2003, 23(5):561-569.CHEN T B, HUANG Q F, GAO D, et al. Heavy metal concentrations and their decreasing trend in sewage sludges of China[J]. Acta Scientiae Circumstantiae, 2003, 23(5):561-569. [5] 马瑾, 潘根兴, 万洪富, 等. 珠江三角洲典型区域土壤重金属污染探查研究[J]. 土壤通报, 2004, 35(5):636-638.MA J, PAN G X, WANG H F, et al. Investigation on heavy metal pollution in a typical area of the pearl river delta[J]. Chinese Journal of Soil Science, 2004, 35(5):636-638. [6] 张灿, 陈虹, 余忆玄, 等. 我国沿海地区城镇污水处理厂污泥重金属污染状况及其处置分析[J]. 环境科学, 2013, 34(4):1345-1350.ZHANG C, CHEN H, YU Y X, et al. Pollution characteristics of heavy metal in sludge from wastewater treatment plants and sludge disposal in Chinese coastal areas[J]. Environmental Science, 2013, 34(4):1345-1350. [7] 韩文君, 刘松玉, 严红霞, 等. 污染土的修复技术研究现状[C]//地基处理理论与技术进展:第10届全国地基处理学术讨论会论文集. 南京:东南大学出版社, 2008:469-472. [8] 林云青, 章钢娅. 黏土矿物修复重金属污染土壤的研究进展[J]. 中国农学通报, 2009, 25(24):422-427.LIN Y Q, ZHANG G Y. Research advances on remediation of heavy metal contaminated soil using clay minerals[J]. Chinese Agricultural Science Bulletin, 2009, 25(24):422-427. [9] SANCHEZ F, BARNA R, GARRABRANTS A, et al. Environmental assessment of a cement-based solidified soil contaminated with lead[J]. Chemical Engineering Science, 2000, 55(01):113-128. [10] JING C Y, LIU S Q, KORFIATIS G P, et al. Leaching behavior of Cr(Ⅲ) in stabilized/solidified soil[J]. Chemosphere, 2006, 64(3):379-385. [11] 薛永杰, 朱书景, 侯浩波, 等. 石灰粉煤灰固化重金属污染土壤的试验研究[J]. 粉煤灰, 2007, 19(3):10-12.XUE Y J, ZHU S J, HOU H B, et al. Experiment study of quicklime-ash solidification of heavy metal contaminated soil[J]. Fly Ash, 2007, 19(3):10-12. [12] CHEN Q Y, TYER M, HILLS C D, et al. Immobilisation of heavy metal in cement-based solidification/stabilization:a review[J]. Waste Management, 2009, 29(01):390-403. [13] VOGLAR G E, LESTAN D. Solidification/stabilisation of metals contaminated industrial soil from former Zn smelter in Celje, Slovenia, using cement as a hydraulic binder[J]. Journal of Hazardous Materials, 2010, 178(1-3):926-933. [14] 席永慧, 熊浩. 锌污染土固化处理实验研究[J]. 同济大学学报(自然科学版), 2012,(11):1608-1612.XI Y H, XIONG H. Experimental study of immobilization of zn-contaminated soil[J]. Journal of Tongji University(Natural Science), 2012,(11):1608-1612. [15] GRAY C W, DUNHAM S J, DENNIS P G, et al. Field evaluation of in situ remediation of a heavy metal contaminated soil using lime and red-mud[J]. Environmental Pollution, 2006, 142(3):530-539. [16] 康兴生, 马涛, 王睿, 等. 河流重金属污染底泥的稳定化实验研究[J]. 环境工程学报, 2015, 9(12):6083-6089.KANG X S, MA T, WANG R, et al. Stabilization of heavy metals in contaminated river sediment[J]. Chinese Journal of Environmental Engineering, 2015, 9(12):6083-6089. [17] 刘莹, 王清. 吹填土沉积后微观结构特征定量化研究[J]. 水文地质工程地质, 2006, 33(3):124-128.LIU Y, WANG Q. Quantitative study of microstructure characteristics of dredger fills after sediment[J]. Hydrogeology & Engineering Geology, 2006, 33(3):124-128. [18] 王宝勋. 海积软土力学特征与固化新技术研究[D]. 长沙:中南大学资源与安全工程学院, 2008. [19] LIANG S H, WANG M, ZHANG L, et al. Experimental study of mechanical properties and microstructures on Nansha soft soil stabilized with cement[J]. Materials Research Innovation, 2015, 19(S8):518-524. [20] 梁仕华, 张朗, 周世宗. 水泥基固化剂固化南沙软土的力学及微观试验研究[J]. 广东工业大学学报, 2015, 32(2):17-22.LIANG S H, ZHANG L, ZHOU S Z. Experimental research of mechanics and microscopic on Nansha soft soil reinforced with cement-based curing agent[J]. Journal of Guangdong University of Technology, 2015, 32(2):17-22. [21] 杜延军, 金飞, 刘松玉, 等. 重金属工业污染场地固化/稳定处理研究进展[J]. 岩土力学, 2011, 2(1):116-124.DU Y J, JIN F, LIU S Y, et al. Review of stabilization solidification technique for remediation of heavy metal contaminated lands[J]. Rock and Soil Mechanics, 2011, 2(1):116-124.
[1] 梁仕华, 陈俊涛, 林焕生, 冯德銮, 龚星, 罗庆姿. 水泥固化淤泥废弃土作为填土材料的试验研究[J]. 广东工业大学学报, 2020, 37(02): 102-106.
[2] 梁仕华, 周锦程, 罗祺, 林焕生. 有机质对水泥固化淤泥土的力学特性影响试验研究[J]. 广东工业大学学报, 2019, 36(06): 86-91.
Viewed
Full text


Abstract

Cited
  Shared   
  Discussed   
No Suggested Reading articles found!
版权所有 © 2017 《广东工业大学学报》编辑部
地址：广州市东风东路729号广东工业大学 邮编：510090
电话：020-37626653,020-37626139,020-37626396
邮箱：xbzrb@gdut.edu.cn
本系统由北京玛格泰克科技发展有限公司设计开发